How much does a coal stoker boiler?

What is a stoker boiler?

A stoker boiler is a type of boiler used to generate steam for industrial processes, heating and power generation. The stoker boiler system was invented in the late 19th century, when large-scale industrial operations began to require more efficient means of utilizing coal.

The stoker system uses pulverized coal injection instead of traditional solid fuel. This process allows for higher efficiency and reduced maintenance costs, as well as better heat transfer properties due to even heating throughout the firebox.

What are the two types of stoker fired boiler?

The two types of stoker fired boilers are single-pass and double-pass.

• Single-pass - In a single-pass boiler, all the fuel is burnt in one pass through the furnace. This type of boiler requires high pressure to force the combustion gases through a system of tubes called a heat exchanger where they give up heat before leaving the system. The heat exchanger is where water is heated by these hot gases so energy can be transferred from them into your home's hot water supply (or for commercial use).

• Double-pass - A double-pass boiler uses two passes through the furnace: once as an air burner and then again as an ash burner (referred to as secondary combustion). These boilers produce less ash than single pass models because some of it burns in each pass though those burners mentioned above.

How much does it cost to buy a coal stoker boiler?

One of the most common questions we get is, "How much does a coal stoker boiler cost?" The answer to this question can vary quite a bit from one model to the next. If you're looking at wood stokers specifically, expect to pay between $15,000 and $25,000 for a new unit installed in your home.

For coal-fired boilers that are designed for residential use, you'll be looking at more like $10,000 for a smaller system or about $20,000 for a larger one. The exact price of your installation will depend on factors such as whether or not it needs additional structural support and whether or not there's room inside your house (or garage) where installation can take place without interrupting daily life too much.

Finally we have pellet stokers which tend to run around $25k depending on how many BTUs they produce per hour (see below).

Conclusion

The stoker boiler is a great option to consider if you want to heat your home on a budget. It's also easy to install and maintain, which means that even DIYers can take advantage of this efficient heating system.