Volvo Generating Set Engine TAD941GE
by Starlight Generator dieselgeneratortechVolvo TAD941GE is a powerful,
reliable and economical generating set diesel engine built on the dependable
Volvo in-line six cylinder.
Durability
and low noise
Designed for the
easiest, fastest and most economical installation. Well balanced to produce
smooth and vibration free operation with low noise level, featured with high
torque.
To maintain a controlled
working temperature in cylinders and combustion chambers, the engine is
equipped with piston cooling. The engine is also fitted with replaceable cylinder
liners and valve seats / guides to ensure maximum durability and service life
of the engine.
Operational
economy and low exhaust emission
The state of art,
high-tech injection and air charging system with low internal losses
contributes to excellent combustion and low fuel consumption.
The TAD941GE complies
with EU stage 2 and TA-fuft exhaust emission regulations.
Generating
Engine Working Condition Division
Prime rated power: The
rated power meets the standard of ISO continuous operation and is suitable for
continuous power supply under different loads. It has 10% overload capacity.
Rated
Power
Maximum standby power:
The power conforms to ISO standard and can be supplied continuously under
different loads. It is suitable for use in the case of failure in areas with
good power equipment. No overload is allowed.
Governor
function
1. According to the load
change, quickly and automatically adjust the fuel supply. Keep the balance of
output power and load, and maintain a stable speed.
2. Limit the maximum
speed to prevent speeding accidents.
3. Guarantee the
stability of low speed idling.
Volvo commonly used
governor is mechanical governor and full electronic governor.
Mechanical governor:
Induction element is flying iron and
spring mechanism, direct drive actuator. This type of governor is often
integrated with the fuel injection pump and is widely used in small power
diesel engine.
Full electronic
governor: The signal sensing part and actuator are electrical. Small working
capacity, suitable for small diesel engine.
Use
Coolant Correctly
If there is a risk of
cooling at any time of the year, a mixture of 50% purified water (ASTM D4985)
must be added to the cooling system. This mixture can withstand freezing to
minus 40°C and should be used throughout the year.
Note: Even if the
temperature is not as low as minus 40°C, use a mixture of the above ratios to
maintain complete corrosion protection.
Engine
maintenance
Before starting for the
first time every day;
Check engine oil level ①;
Check the coolant level;
Inspect and clean the
outside of the radiator;
Check the air filter
blocking indicator①②③;
Check the engine for
water leakage and oil leakage;
①When used continuously, it should be checked
every 8 hours;
②When the indicator shows a 1/3-1/2 red mark, the
air filter should be replaced.
③When operating in a dusty environment, a special
air filter should be used (not supplied by Volvo Penta)
About
Shutdown
1. The machine should be
run for a few minutes at an empty load before shutdown to prevent overheating.
2. Check for leaks after
shutdown.
3. Close the fuel valve
and the electric door.
4. Record the hours of
operation and complete the required maintenance work.
Note:
1) Run the engine at
least every 14 hours if the engine is not used frequently, and let it reach the
working temperature to prevent corrosion;
2) If the engine is
stopped for more than 2 months, an anti-rust oil seal should be applied.
Avoid running at idle
and low load for long periods of time
This type of operation
will result in:
1. The consumption of
lubricating oil is high;
2. Leaking fuel or
lubricating oil in the exhaust manifold;
3. Turbine shaft seal
oil leakage of turbocharger;
4. Severe carbon
deposits on the piston, piston ring groove, valve and supercharger;
5. Low combustion
temperature will result in incomplete fuel combustion, resulting in dilution of
the lubricant.
Starlight Power
manufactures Volvo generator power range from 85 kva to 750 kva rated/standby
diesel generator set. Contact us to get the price now!
Sponsor Ads
Created on Nov 4th 2019 20:25. Viewed 231 times.